|Topic Review (Newest First)|
|06-20-2019 01:30 PM|
Pull the cover next to the battery and fold up the rubber cover on the starter relay and check the fuse. Should be 20 amp stock, for some reason I have found some previous owners have put a 30 amp fuse on the starter relay. Should be another one under the starter relay.
|06-19-2019 07:29 PM|
The main is designed to blow and I will bet that is what happened. Did you check the main fuse?
Check all of them.
Based on your car 'jumping' episode, if a fuse is not the culprit, I recommend you get a multimeter to check electrical components.
Take the battery out and see if it can be charged.
Wondering: did you do a post to post connection or ground the running car when you attempted to start the bike? If former, check electronics, see kryton's note. If latter, check the main fuse. It is there to save your components and if it 'works' it blows. Did you have power (headlight/dash) when you immediately connected it to the running car) before engaging starter? IF all went dead after engaging starter, I would bet you blew the main.
Push starting should work (next time) on a almost dead battery provided the stator is ok. Check stator with multimeter (easily done form plug under seat)
New CDI (Capacitive Discharge Ignition) units are available from Jack's Rebel Warehouse in FL. Lots of other stuff to try before replacing and you can check it with a multimeter too
Flight makes some good points based on your location, but parts can be found. There are a couple of guys across the pond that do a lot with 450's. There is a guy in Italy who only does 450's on Facebook. search for Leo Van Mil and check out his 450 parts page, lots of info and he is much closer to you. I kinda wish he lived here!
I (personally) would use the customizations and car jumping episode as 'leverage' to get the bike, AS-IS, for a much cheaper price. If you have seen this bike running, I am sure it will not take much to get it started. Just need to diagnose thoroughly.
|06-18-2019 11:08 AM|
forgive me for oversimplifying this: Car alternators are computer regulated, and when running with a very dead motorcycle battery attached, the car's computer would try to compensate, and could push 18v+ down the jumper cables and fry your electronics.
if the motorcycle battery is just a little bit low and not dead this probably won't happen.
|06-16-2019 11:14 PM|
Originally Posted by Daren4ch View Post
|06-16-2019 05:21 PM|
Originally Posted by flitecontrol View Post
|06-16-2019 02:15 PM|
There are a few 450 bikes in Europe whose owners are members of this forum. They might know sources for parts.
I'm pretty sure the CDI for the 250 Rebel isn't interchangeable with the 450. The turn signals are interchangeable, but not a whole lot more.
That would be a fair price for a stock (unmodified, all original parts) bike that didn't need major repairs here in the U.S. But if the electrical system is fried, and the tank and carburetors need cleaning, you might try and negotiate a lower price. If cleaning the tank reveals small holes, that further reduces the price. Holes in the tank can be repaired using an epoxy liner. This is what we use here: https://www.caswellplating.com/epoxy...nk-sealer.html
|06-16-2019 01:20 PM|
Originally Posted by flitecontrol View Post
thank's a lot for the reply
the car was running when tried to start the bike mutiple times
i'm from romania , anything i order overseas takes ages to get to me :<
need to find a source in EU / UK
i think there is rust in the tank , cause the owner forgot to put petrol in it before letting the bike in the winter
can i get cdi from the new rebels ? also other parts fit from the new rebels ?
also what do you think about the price ? should i go for it ?
|06-16-2019 01:15 PM|
Welcome to the forum. As you may know, jumping a bike battery from a car can be done safely, but the car engine should be off when it is done. If the car engine was not running when jumping the bike, I suspect there may be some other electrical issues.
Your friend may have just blown some fuses, which is an easy fix. Has that been checked?
CDI and the starting motor do fail occasionally, but replacement parts are still available from Honda or other sources. Jacks Rebel Warehouse here in the U.S. sells a quality replacement CDI, and has a good inventory of used parts. He does ship overseas. Because the starting motor is inside the engine, repairing it requires splitting the cases.
If the bike was running well when put away for winter, the carbs shouldn't need cleaning, even if the fuel wasn't drained first. Draining the carburetor before storage is recommended. When the electrical issues are resolved, drain the old gas and put fresh in. Look inside the tank and see if there is visible rust. If there is, the tank should be cleaned and an inline fuel filter installed to keep any contaminants from reaching the carb. There is a video on installing an inline fuel filter here: https://www.hondarebelforum.com/f39/...ter-13278.html
The 450 is a pleasure to ride. Not too heavy , good power, and with the six gears, very smooth at highway speeds.
Because the bike was only produced for two years, it can be difficult to find used parts if there weren't many sold in your country.
|06-16-2019 12:20 PM|
oportunity to buy the 87 rebel 450
hello there , i'm new here . glad to see you guys
i have some question if it's not a problem to ask , but want to know an second oppinion regarding my purchase
i have an oportunity to buy the 87 rebel 450 locally from a friend for like 1000$ , broken . heard that they are very rare
it worked perfect till this summer , when it ran out of battery from standing in the winter , and he tried to give power from a car , and damaged some things ( yes , very stupid )
the service guys said that it needs some parts + oil change , filters cleaning carbs etc
he said he needs new CDI or new BOBINA ignition motor ( hope i m writing corect in english )
he doesn't know exactly which of this two needs to be replaced
and the " BENDIX " sounds like it doesn't have much life , and need to be replaced too
what's your oppinion about this ? should i get it , repair it and put it on the streets ? i love it cause it's made custom , bobber
can i find this parts ? or it's very hard to find them ?
here are some pics of the rebel 450 . The yellow vespa 2019 , 300cc it's mine
thanks a lot in advance